Arkansas STEPS Excavation Training - April 5, 2017

1
Ver 3.0 9/01Copyright Occupational Risk Solutions, Inc. Denver © 2004
Trench Safety Course
Excavation Safety
q The death rate for a trench  
related incident is 2 1/2 times greater  
than for any other construction related event!
q It is estimated that there are more than 10,000
entrapments each year. (About 10% of which
result in lost-time” injuries)
Hazards of Trenching

2
Trench Deaths and Injuries
❑  Conservative estimates put the number
of deaths from cave-ins at near 100 per
year!
❑  Additionally, another 100 persons are
permanently disabled and cannot return
to work!
❑  Nearly 200 more are injured to the extent
that they cannot perform the same duties
and must be retrained!
4
Law of Effect
Current Behavior (CB) = Current Situation (CS)
+ Past Experience (PE)
CB = CS + PE
Unsafe = In Hurry + No prior
Trench Resources incidents

3
Ver. 3.0 09/04Copyright Occupational Risk Solutions, Inc. Denver © 2004
Cave-in
The separation and movement of soil into
an excavation:
q Either by falling or sliding
q In sufﬁcient quantities  
that it could:
◆  Immobilize
◆  Entrap
◆  Injure
◆  Bury
How Quickly do Cave-ins Occur?

4
Post- Fatality / Injury Inspection
After the fact inspections are the most difﬁcult for a
contractor to defend against because:
A highly predictable, preventable event has occurred.
q PREDICTABLE: There are no permanently vertical
soil or rock walls found in nature!
q PREVENTABLE: There are MEANS (equipment) or
METHODS (work processes) available which will
prevent worker exposure.
CONCLUSION: Cave-ins are not accidents!
4.5 Deep Trench
Would you
put shoring
in this
trench?

5
Weights of Materials
§  Dry Sand=80-90 lbs.
§  Dry Clay=85-90 lbs.
§  Wet Clay=110-125 lbs.
§  Wet Mud, =120-125 lbs.
§  Limestone=160 lbs.
§  Granite=165 lbs.
Weights of Soils (Averages)
What Causes the Cave-In?

6
Common Sense ?
This pipe repair in
Pittsburgh in the
winter of 1997 was
completed without
the benefit of any
shoring!

7
Leadership Role
A safety Officer for
a major N.W. city
only needed to be
in the trench for a
few minutes!
This backhoe operator is
having second thoughts
about the days events
which resulted in the
death of the company
owner!
North Carolina Tragedy

8
Excavation Site Hazards
Do Not Leave Protected Area

9
Albuquerque New Mexico
An employee died
in this moist
sand trench!
A Life Cut Short
Shoring had not
been installed
so that the job
could progress
faster!

10
Improper Access-Egress
Double Fatality

11
The owner and his two
employees all claimed that
this excavation was sloped
and less than 5 in depth
when confronted by the
compliance officer.
Water Park Trench Collapse
Water Park Trench Collapse!
Two men were
trapped in this
trench as co-
workers and
rescuers worked
frantically to
extricate them!

12
Improper Loading

13
Spoil
Pile
Utility
Pole
Structures
Equipment
Surface Encumbrances

14
Assess The Hazard Potential
Broken Water Line

15
Proper Use Of A System ?
Tabulated Data

16
Manufacturers Tabulated Data
Should Address Every Anticipated Hazard
The Affected Zone

17
Mobile Equipment At Excavations
USE:
Mechanical Signals
Hand Signals
Barricades
Stop logs
To prevent entry into the excavation
Rescue Planning

18
End
General Requirements

Arkansas STEPS Excavation Training - April 5, 2017

Recommended

Recommended

More Related Content

More from Arkansas STEPS Network

More from Arkansas STEPS Network (12)

Recently uploaded

Recently uploaded (20)

Arkansas STEPS Excavation Training - April 5, 2017